Humidifier Maintenance

 How whole house humidifiers are supposed to work . . .

 

When the humidistat is calling for humidity (and the furnace is running) a solenoid valve will open and allow fresh water to flow across a porous evaporator pad.  The water supply starts from a saddle valve attached to a water pipe.  Water flows through a tube to a solenoid valve equipped with an inline water strainer.  The valve electrically opens and closes to control the supply of water, and the strainer filters particles from the water.   Filtered water  then goes through the orifice which meters the water through a 1/4" feed tube (usually plastic) to the water distribution tray.  From the distribution tray,  water flows by gravity into the water panel evaporator (sometimes called a "filter pad") where part of the water is evaporated and enters the home's air supply ducts.  Once the pad is saturated, the overflow water flushes the majority of minerals left after evaporation off the water panel pad.  The water drains via a 1/2" drain tube through a drain spud at the bottom of the humidifier.

Humidifier Maintenance - Northville Michigan Home Inspector - filter

A flow-through humidifier is a relatively simple piece of equipment.  The only real "moving part" is the solenoid valve, which opens to allow water flow to the humidifier.  Still, flow-through humidifiers do need occasional maintenance.  

Maintenance Tips:

Change your water panel.  The typical water panel (or evaporator pad, or filter) in the humidifier is constructed of an expanded aluminum honeycombed mesh dipped in a ceramic slip (liquid clay).  The large surface area of the clay material is perfect for absorbing water.  When openings in the water panel become clogged with scale and mineral deposits, they will restrict airflow through the pad and should be replaced.  The life of the water panel evaporator will vary with the hardness of the water, the amount of use, and the application.  Is ins recommended that the water panel be changed at least once every year. 

Humidistat Setting:

Humidifier Maintenance - Northville Michigan Home Inspector - humidistat

Be sure to set your humidistat at the recommend setting listed on the unit. The amount of humidity varies depending on exterior temperature. 

Silicon Caulk Application
How to replace silicone caulk.
Read More...
Water Heater Maintenance
Water Heater Maintenance
Read More...
How To Prevent Termites
Although termites are more common in older homes, termite control can even be a problem in brand new homes. When builders clear trees from a site to build new homes, the termites can migrate to the wood stored on the site. A concrete slab or brick construction is no guarantee that termites will not eventually invade a home because termites can work their way up through the ground into minuscule cracks in the concrete
Read More...
Common Defects
With common issues it's typically a matter of a relatively simple fix to correct the issue, however left alone some of these issues could result in easily avoidable larger issues down the road. While conducting my home inspection I feel it's my job...
Read More...
Downspout Extensions
This should have been added to my Common Issues Blog being one of the most common installations. While installing downspouts so they terminate above the roof surface isn't a "defect" I always recommend routing downspouts to the gutter...
Read More...
Dryer Vent Safety
Clothes dryers evaporate the water from wet clothing by blowing hot air past them while they tumble inside a spinning drum. Heat is provided by an electrical heating element or gas burner. Some heavy garment loads can contain more than a gallon of water which, during the drying process, will become airborne water vapor and leave the dryer and home through an exhaust duct (more commonly known as a dryer vent).
Read More...
Electrical Safety
Electricity is an essential part of our lives. However, it has the potential to cause great harm. Electrical systems will function almost indefinitely, if properly installed and not overloaded or physically abused. Electrical fires in our homes claim the lives of 485 Americans each year and injure 2,305 more. Some of these fires are caused by electrical system failures and appliance defects, but many more are caused by the misuse and poor maintenance of electrical appliances, incorrectly installed wiring, and overloaded circuits and extension cords. Some safety tips to remember:
Read More...
Environmental Concerns (Asbestos)
The Ancient Greeks named the mineral asbestos, meaning inextinguishable. Apparently even the Greeks were aware of the harmful properties in asbestos and the effects of breathing asbestos dust. The Greek geographer Strabo and the Roman naturalist Pliny the Elder mentioned a sickness common with workers who created cloths using asbestos fibers.
Read More...
Galvanized Steel Plumbing
Where water pressure is poor in the distribution system, the most common cause is corroded galvanized steel. Galvanized plumbing can close down so that the inner diameter is reduced to 1/8” or less. The only solution is to replace the plumbing lines, typically with copper.
Read More...
High Efficiency Lights
Environmentally friendly lights/Mercury Vapor.
Read More...
Ice Damming - Roof Leaks
A typical ice-damming event occurs when the heat escapes from the living quarters into the attic and eventually warms the roof deck. The combination of the sun and the interior heat combine to accelerate and exacerbate this process.
Read More...
Inspect Before Listing
Having a pre-list inspection will give the seller the opportunity to repair or upgrade those items that will no doubt be pointed out during the purchase inspection. Being able to limit the number of items needing attention will increase the marketability of the property being sold.
Read More...
Radon
Radon, because it is a gas, is able to move though spaces in the soil or fill material around a home's foundation. Michigan homes tend to operate under a negative pressure - this is especially true in the lowest portions of the home and during the heating season.
Read More...
Sump Pump Operation
Sump pumps are self-activating electrical pumps that protect homes from moisture intrusion and are very common in Southeastern Michigan homes. They are usually installed below basement or crawlspace floors to remove rising groundwater and surface runoff before it has a chance to seep into the home.
Read More...
TPR Vales and Discharge Piping
TPR (temperature pressure relief) valves are safety devices installed on water heating appliances such as boilers and domestic water supply heaters. TPRs are designed to automatically release water in the event that pressure or temperature in the water tank exceeds safe levels.
Read More...
Aging in Place
"Aging in place" is the phenomenon describing senior citizens' ability to live independently in their homes for as long as possible. Those who age in place will not have to move from their present residence in order to secure necessary support services in response to their changing needs.
Read More...
Ash Tree Enemy
Damage to Ash trees throughout the United States.
Read More...
Bats in the attic
Bat guano can build up in attics and eaves that have been used by bats, and even if the human occupants of the building are not aware of the dung, they may be harmed by it.
Read More...
* Indicates required questions
Name *
First Last
Email *
Phone # *
Property Address (Include City) *
How can we help you?
VerificationCode
Enter code in image: